Graph of CRNA usage for optimized Surgeon Schedule

Distribution of total CRNA work hours for optimized surgeon schedule

also see: FTE vs cost accounting … when PUNs equal CUEs

also see: Wasting surgeons’ time

This is a graph of the CRNA usage for the Optimized Surgeon schedule from the blog post dated Jan 20, 2010.   Compare this graph to the ones in the blog dated Jan 17, 2010 “Do you know where your CRNAs are?“.   The total amount of actual working time for the CRNAs in this graph is 157 hrs instead of 147 hrs in the actual non-optimized graph, mostly because I rescheduled a 7 hr neurosurgical case from around midnight to earlier that day to see the effect of moving quasi-emergency cases that could have been accomplished earlier if there had been time available.  In addition there will be some discrepancy because of variations in anesthesia preparatory time for the first cases of the day.

For a different graphic view of crna employee time paid vs crna down time see the following graphs.  Each red square represents a 10 minute period during which 100% of the time the CRNA is clocked in she’s actually involved with a case (generating revenue) as indicated on an anesthesia record. Green represents less than 100% of the 10 minutes (1-10).  Yellow means that the CRNA was being paid a salary but not bringing in revenue.

Actual schedule:

Hours being billed vs hours being paid

Hours being billed vs hours being paid

versus optimized:

CRNA hours billed vs paid in theoretical optimized schedule

CRNA hours billed vs paid in theoretical optimized schedule

Each line represents an OR room. The CNRAs in the bottom ‘optimal’ graph move from room to room with cases as needed to keep the surgeon busy, hence there are 30 rooms (lines) used instead of the 26 rooms (lines) in the top graph. The CRNAs in the top (actual, non-optimized schedule) tended to stay in one room (lots of idle time) instead of being optimally reassigned to other rooms with cases. As you can see, in the top graph there are long stretches of yellow squares (idle time) between red squares for many CRNAs. The bottom ‘optimized’ graph also has an extra 6 hour neuro case that I moved forward (not included in top graph) from later that night.

CRNAs often work a set number of hours a week (not per day). The trick is to have them working while they are present, and not waiting on cases. .These two graphs relate to my blog when PUNs equal CUEs  which discusses FTEs.  Tracking and effectively scheduling CRNAs can bring the ratio of CUE/PUN closer to 1. Scheduling surgeons well throughout the day also decreases their sTOT (CUE/PUN closer to 1). Both can be accomplished simultaneously as shown by the surgeon’s graph for this same optimized day: Wasting surgeons’ time.

Notice that the maximum amount of CRNA hours working at any one time in the optimized schedule is closer to 25, less than the 28 that were hired for the actual non-optimized schedule.  This maximum load is from 8 am to 9 am which means that more cases are being completed earlier in the day.  Compare that to the actual schedule which had it’s maximum usage between 10 am and 1 pm  with only 18 -19 CRNA hours being in use at that time. Many of these extra early starts are due to preparation of  a second (flip) case while the surgeon is still working on his first case of the day.

The maximum number of CRNAs can be reduced by covering 2 rooms with only 1 CRNA.  Depending on the type case and surgeon, a fast CRNA can cover the same surgeon in two rooms, thus decreasing the total number of CRNAs needed.  Increased pay (or other compensation) would be a good incentive for the CRNA to discover ways to quicken turnover.  This applies to anesthesiologists as well; if on salary, a differentiation in pay is a good incentive to discover ways to quicken turnover.  A corollary of this is that you should put slow CRNAs and anesthesiologists on long cases or on cases where it is not feasible for other reasons to have the anesthetist cover more than one room at a time.

The optimized case schedule is pretty much over between 4 and 5 pm while the actual non-optimized schedule drags on.  Significant overtime pay can be saved by optimizing the cases.  As for CRNAs, 24  were clocked in by 7 am in the actual schedule, with 14 being clocked in by 6 am or earlier, so there wouldn’t be much, if any, increase in timesheets on the front part of the day, but a significant decrease later in the day.  Depending on how many cases you want to complete early, you could shift the schedule to decrease the maximum CRNA usage while not increasing the surgeon total time in the OR.  The surgeons could come in a later, but still have a much shorter total stay.  The fact that many surgeons do not arrive in time to take advantage of as early a start as possible leads one to conclude that they may be more interested in total time in the OR and the ability to finish their cases by a certain time of day.  The early start could be just an attempt to finish early, but it is not the only way to finish early.

There are many considerations in optimizing the case load schedule in a particular hospital.  What works for one won’t for another.  Staggered start times also should be considered.  Anyone who has worked in a busy OR is aware of the 8 am (or 7 am) OR congestion from trying to start too many cases at the same time.  The effects can be similar to the morning rush hour traffic jam with everyone losing time.  Again, it may not be the early start time that the surgeon most wants, but a shorter total time in the OR.

About Brian D Gregory

Board Certified Anesthesiologist for 20 years. MBA from U of Georgia '90: Finance, Data Management, Risk Management. Practiced in multiple US states and Saudi Arabia at KFSH&RC. Taught residents in two locations. Worked with CRNAs for 20 years.
This entry was posted in anesthesiologist, scheduling and tagged , , , . Bookmark the permalink.

Leave a Reply

Fill in your details below or click an icon to log in:

WordPress.com Logo

You are commenting using your WordPress.com account. Log Out / Change )

Twitter picture

You are commenting using your Twitter account. Log Out / Change )

Facebook photo

You are commenting using your Facebook account. Log Out / Change )

Google+ photo

You are commenting using your Google+ account. Log Out / Change )

Connecting to %s